Hypo Allergenic

Hypo-Allergenic Powder Compound

Question: How do Murco Hypo powder compounds differ from regular powder joint compounds?

They differ greatly in chemical content. They contain no preservatives, mildewcides, fungicides, VOC (Volatile Organic Compounds), amines, formaldehyde, vinyl acetate, or any petroleum products.

Question: How do the Murco Hypo joint compounds differ from regular compounds on the finished job?

The M-100 is slightly harder and does not sand as easy and may not take structure movement as much as some other compounds, however it is tougher than regular compounds.

Question: How about the application process?

Both powders can be mixed easily. (Mix heavy until lumps are gone, then thin to desired consistency.) Be advised since neither powder contains preservatives, only mix what is needed to be used in one 24hr period, as bacteria could become a problem once water is added.

Question: Can the Hypo products be used for texture?

Yes, the M-100 is recommended for texture, but if heavy/thick texture is required we recommend the setting compound be used.

Question: How much material does a 25lb or 18lb bag make when mixed with water?

Approximately 3 gallons.

Question: Will there be any out gassing with these products?

The only volatiles that will be out gassed will be the water that is added.

Question: Can the M-100 be used in automatic taping tools?

Yes. Murphy also manufactures Tapeworm Taping Tools.

Question: How about painting, and will the products seal and prevent out gassing from wallboard or other surfaces they are applied on?

Painting is no different than any other compounds. But neither product is “vapor proof.” (Meaning vapors will pass through.) So they will not stop out gassing from wallboard or substrates underneath.

Question: What is the cost of these Hypo products?

Both are reasonably priced, just contact the dealer nearest you.

Hypo-Allergenic Paints and Primers

Question: How are the Hypo Paints different from conventional paints?

First, they contain extremely small amounts of VOC (Volatile Organic Compounds). These are mostly petroleum based solvents. Second, some of the volatiles (not considered VOC’s) have also been removed. Finally, they contain no fungicides or mildewcides. The result of these changes produce a paint that has very little if any odor.

Question: What types of paint are in the Murco Hypo line?

A drywall surface primer, a stain stopping primer, a flat wall paint, and a satin wall paint.

Question: Do you offer a gloss in this line?

Murco has a gloss paint that has a low VOC and no fungicides and no mildewcides but to achieve the higher gloss, the VOC content is too high for this particular line.

Question: How about the performance and durability of these Hypo Paints?

The finished job using these paints is not affected as far as durability, coverage, and looks. They are not protected from mildewcides so avoid prolonged moisture exposure.

Question: Can the stain stop primer replace oil based primers?

Yes, in most cases. However it does not adhere to raw unprimed steel and does not have the rust resistance that oil primers normally have.

Question: Can the drywall surface primer be used to achieve a Level 5 Drywall finish?

Yes, it is a true drywall surface preparation primer, and can be applied at a very high film thickness.

Question: Will any of these Hypo Paints seal or stop out gassing from paints or wallboard underneath there film?

No, vapors will pass through all of them. The stain stop primer, which itself has a slightly higher VOC, can stop up to 90% of vapor transmission through its film.

Question: How about the application of these paints?

All can be brushed, rolled, or sprayed. (These paints should not be applied or stored at temperatures below 50° F) Before application make sure wall, air, and product temperature are above 50° F.

Question: How about tinting colors with these paints?

All, with the exception of the stain stop primer, can be tinted to light colors. Do not tint the stain stop or it may inhibit its ability to stop stains. Also keep in mind that a lot of the things removed from these paints can be added back in with the tint. Also be aware that even some of the tints advertised as VOC Free contain solvents that are not classified by some organizations as VOC Free.

Question: How about using these paints on exterior surfaces?

None of the Hypo Paints are recommended for exterior use.

Question: What would be the primary use for these paints?

These Hypo Paints are ideal for doctors offices, churches, schools, bedrooms for infants or small children, or anyone that would prefer breathing cleaner air. They are also good for the environment as they contain less ozone depleting contaminants.

Question: Are these latex paints?

Yes, all contain latex.

Question: How about the cost of these products, as most low VOC paints are very expensive?

All products in this line are comparably priced to conventional paints, and in some cases could be less expensive.